Call Us Today! 757.565.7222
sales@henryequipment.com

2015 McLanahan Sand and Gravel Wash Plant

SOLD 2015 McLanahan Sand and Gravel Wash Plant
2015 McLanahan Sand and Gravel Wash Plant 2015 McLanahan Sand and Gravel Wash Plant
2015 McLanahan Sand and Gravel Wash Plant 2015 McLanahan Sand and Gravel Wash Plant

$400,000.00 USD

Year: 2015
Make: McLanahan
Model: Sand and Gravel Wash Plant
Category: Aggregate / Crushers / Screening

Stock# 2263

Hours: N/A
SN#: N/A
VIN#: N/A
Location: Virginia

Complete 2015 McLanahan Sand and Gravel Wash Plant....400TPH Sand & Gravel Wash Plant.... The plant is up and running. It is being sold only because the owners have run out of deposit at this site. This plant was modified in 2015 the existing 2008 H&B Plant to facilitate the production of ASTM C33 concrete, Mason Sand, Golf Course Sand, and Clean Gravel Products #3, #56, and #8 at a targeted production rate of 300 TPH. It is in very good condition and being sold “AS IS WHERE IS”.... Call Mark Hockaday today and make an appointment to come inspect the plant....Location: VA..... PRICE: $400,000.00 USD ........... Make a Reasonable Offer…Stock #2263.... Call Mark Hockaday at Henry Equipment Sales Inc. 757-565-7222 or Cell 757-592-1602 .........................................................<br /> <br /> See Below Plant Components: Structures: 2015 (1) Wash Screen Tower Heavy duty screen wedge 4 side walk around access Roll away chute box fabricated with ¼” mild steel plate and lined with 3/8”” thick AR 400 Fine’s hopper/flume line fabricated with ¼” mild steel plate and lined with 3/8” think rubber liner Pre-wet box fabricated with ¼” mild steel plate and 3/8” thick rubber liner Ladder/Walkway access to grade, C3, sank classifying tank, feed box………. (1) Classifying Tank Support Horizontal beams under tank Walkway under the tank Structural steel and x-bracing support as required Stair access to grade Product flumes fabricated with ¼” mild steel plate and lined with 3/8” rubber…….. (1) RCC Surge Transfer Bin Dimensions: 8’ x 8’ x 8’ fabricated with ¼” mild steel sides and 3/8” mild steel bottom plate 2” thick AR400 wear bars around discharge opening…….. Wash Screen complete with Media: 2015 (1) Deister HT-2616 Heavy Duty Inclined Vibrating Screen to include: H beam base with c/w motor support 25 HP, 1800 RPM, 3/60/480, TEFC, fame 284-T Toshiba Quarry Duty Motor 3/8” think rubber lining on top and feed sides of cross supports 2” thick rubber discharge Lip Liners 2” thick rubber feed box liners Snubber guards Complete spray system Spring removal system and bolt on jacking system (1) Polydeck Screen Media Solution – estimated - specification to be determined 1. Top deck – (45-55 mm modular system) *wire media may be applicable on discharge end 2. Bottom Deck – (30 mm modular system) Modular system includes media, steel framework, and side wear plates………................................<br /> <br /> Sand Processing Equipment: 2015 (1) McLanahan 10ft x 40ft Sand Classifying Tank to include: 11 valve stations and 3 lined collection flumes Modular handrailing Sand Manager PC monitoring software Rising current stations (3) (1) McLanahan 44”x33’ FMDSW 2- 25 HP motors Standard supports at product end Product discharge chute (1) McLanahan 36”x27’ FMSSW 25 HP motor Standard supports at product end Product discharge chute (1) McLanahan 4”x4” Slurry Pump with Drive Field replaceable molded rubber casing liners Molded rubber impeller with internal steel skeleton Type ‘D’ gland Grease lubricated bearings Overhead motor table 25 HP, 1800 RPM, 230/460 volt 3-phase, 60 cycle TEFC, inverter duty V-belt drive sheaves, belts, and guards 4” x 5’ suction hose (1) McLanahan Feed Collecting Sump (Model E500-FW) Steel fabrication Sloping sides to prevent solids build up Velocity break feed well with rubber lined impact plate Standard flanged pump suction connection 6” drain port………………………………………………...............<br /> <br /> Conveyors: 2015 (1) Like New RCC 30” wide x 63’ long 15 HP conveyor/belt feeder with catwalk (1) Like New RCC 30” wide x 143’ long 30 HP screen feed conveyor with catwalk (1) Like New RCC 24” wide x 115’ long 5 HP transfer conveyor with catwalk (1) Like New RCC 24” wide by 100’ long 7 ½ HP fixed stacking conveyor with catwalk Control House: 2015 All Plant Controls with All Electrical Switchgear 2008 H & B Plant: is a 2008 but was not installed until 2012. With is plant we ran mostly gravel then in 2015 we installed the sand plant side of it. 2008 (2) Radial Stacking Conveyors 2008 Tycan 600L Class Srceen Deck 5’ x12’ with (2) Decks (This one is in need of repair but we have a extra one in shop that will work) 2008 High Pressure Washing Unit. Hydro-Clean HC-2000 Piping: 2015 Plant Water Piping & Waste Water Piping. Electronic Instruments & Switchgear: 2015 can be removed, but the Control House is not being sold. Water Pump: is AA Rotating Apparatis Corp.High Thrust VHS Pump SN 80005334S. It is a 10” or 12” Pump w 250Hps. It floats on water and has a floating dock with catwalk. Spare Parts: 2015 & 2008 We have Panels for the Deister BHT-2616 & Rubber Flap. We have extra V Belts and some conveyor components. We also have a 2008 Tycan Dewatering Screen and a used single McLanahan 44’ x 33” Sand Screw. ***See Below full Description: (We started operating both plants in October 2015)*** McLanahan side of the plant was done in 2015. It has the capability to run up to 400 TPH. Feeder Hopper dumps raw material onto a 30” belt that feeds material to another 30” Conveyor Belt. This Belt feeds material to the Deister BHT2616 Screen that separates the sand and gravel, it also takes off the oversize material. The sand goes into the McLanahan 10’ x 40’ Classifier Tank that separates sand into concrete sand, mortar sand and golf course sand. The gravel is conveyed back to Feed Hopper. Concrete sand is run into a Twin 44” x 33’ McLanahan Sand Screw. The mortar sand and golf course are conveyed into (2) 36” x 27’ McLanahan Sand Screws. All the sand is then stock piled by (3) different conveyors. The gravel leaves the Hopper on a 30” conveyor belt and dumps into a holding hopper on top of the H & B Plant. It is then dumped into the Hydro Cleaner which cleans the gravel, it also has (2) Boast Pumps to help wash the gravel. Then the gravel is conveyed to a Tycan L-Class Flat Screen Note: (This Screen needs to be replaced or rebuilt). The gravel is them washed on a Screen Deck and separated into (3) different products #7 pea-gravel, #57 ½ “to 1 ½ “and Oversized. The #7 gravel and #57 gravel are stockpiled by conveyors. The fines from the Tycan L-Class screen are pumped and piped to the Sand Tank.<br /> <br /> Call us today for more information pictures, video, or to setup an appointment. Henry Equipment Sales Inc. Mark Hockaday 757-565-7222 or Cell 757-592-1602...